PV1
Site Moderator
Posts: 2966
Joined: Fri Apr 27, 2012 4:22 pm
Location: Pittsburgh, PA
Contact: Website

Re: Annual inspection and "required" maintainence?

Tue Jan 21, 2014 7:23 am

I've taken my car for the 1-year service and recalls (SW update, brake pump), actually only had it for 2-3 months, but the wrench came on. I highly doubt the did the battery check, as they told me it was OK, but didn't have any test results.

I've also taken it to the dealer twice for a bad airbag impact sensor, which I guess was also a recall, but the dealer didn't recognize it as one.

All 3 visits, free full recharge and no cost for service. Didn't wash it, though. Haven't yet rotated the tires, and I haven't seen much of any wear on the tires after 9,000 miles.
:idea: :idea: :idea: :!: :!:

Dropbox maintenance in progress. If any of my links aren't working after November 17, please PM me and let me know which one isn't working.

Thanks.

Lief
Posts: 9
Joined: Mon May 16, 2016 3:28 am

Re: Annual inspection and "required" maintainence?

Wed Aug 10, 2016 10:50 pm

(Bought my 2012 a couple mths ago. Check out my fuelly. http://www.fuelly.com/car/mitsubishi/i- ... ief/438800 Wife is worried about spinning around in Winnipeg winters. I doubt i really need this maintance? Here is my emails between the dealer.)

Good day, Lief.

Annual maintenance is $250.00. we will need the vehicle for a full day, as part of this is completely discharging the battery, then fully recharging.
At this time, a winter tire package for this vehicle is $1492.06. this will include Dunlop Graspic DS-3 mounted on steel rims with tire pressure monitor sensors, labour and programming. Prices are subject to change by Fall.
We offer the MPI low-interest rate financing program as well for the winter wheels.

Regards,

Hi Robert thanks for writing back.
My back is 175/60/R15
Front is 145/55/R15

*What would entail in the annual maintenance of an iMiev? Price?
Plus,
I found some winter mat ideas on a iMiev forum.

Thanks for your time,
Lief

Good day, Lief.

There were 2 different tire sizes available for your vehicle, but the VIN will not distinguish the difference.
Can you please let me know what your tire size is (145/65R15 or 175/60R15)

Regards,

PV1
Site Moderator
Posts: 2966
Joined: Fri Apr 27, 2012 4:22 pm
Location: Pittsburgh, PA
Contact: Website

Re: Annual inspection and "required" maintainence?

Thu Aug 11, 2016 5:40 am

I don't know what kind of winter weather you have, but I've made three winters so far on the stock Enasave tires in hilly Pittsburgh. On the road, the car is a champ. The only time it slips is when driving on ice, but any vehicle will slip on ice.

As for annual service, I stopped taking the cars in for it. I don't know what they actually check, but most of the stuff on the car, I can check myself (linkages, tires, brakes, etc.). With the Android apps CaniOn and EVBatMon, we can check battery health ourselves (CaniOn shows individual cell voltages on a graph, and EVBatMon displays Ah capacity of the pack among tons of other features). Regular maintenance can be summed up in tires, windshield, and windshield washer fluid.
:idea: :idea: :idea: :!: :!:

Dropbox maintenance in progress. If any of my links aren't working after November 17, please PM me and let me know which one isn't working.

Thanks.

JoeS
Site Moderator
Posts: 3630
Joined: Thu Dec 15, 2011 5:47 am
Location: Los Altos Hills, California

Re: Annual inspection and "required" maintainence?

Thu Aug 11, 2016 10:40 am

Lief wrote:...as part of this is completely discharging the battery, then fully recharging....
That part has always bothered me, as it simply subtracts another full cycle from the battery life; after all, it was Mitsubishi which sent out a letter saying that one full recharge from two bars every two years is sufficient, and I'm sure most of us do it far more often. Correct me if I'm wrong, but all that does is top-balance the cells and update the car's internal capacity calibration. I'd be even more worried that after doing this they'd leave it sitting outside in the hot sun. :roll:
EVs: 2 Wht/Blu SE Prem., '13 Tesla MS85, 3 156v CorbinSparrows (2 Li-ion), 24v EcoScoot(LiFePO4)
EV Conv: 156v '86 Ram PU, 144v '65 Saab 96
Hybrids: 48v1kW bike
ICE: '88 Isuzu Trooper. Mothballed: '67 Saab (orig.owner), '76 MBZ L206D RHD RV

siai47
Posts: 361
Joined: Fri Jun 14, 2013 5:54 pm

Re: Annual inspection and "required" maintainence?

Fri Aug 12, 2016 6:46 am

The battery capacity test isn't a bad thing----and it is something I would require if purchasing a used I-MiEV. The BMS hides any battery degradation until they are really in bad shape and the range drops quickly. Anyone who owns an I-MiEV should also have the CANION program to monitor the battery pack. Every two to three years any vehicle with ABS brakes should have a brake fluid flush to remove any moisture in the system. Tire rotation? You can only go left to right on the same axle but in some instances it might help. For anyone who lives in areas where road salt is used, the underbody of the car should be flushed each spring with soapy water to get the salt residue out of all the nooks and crannies under the car. I feel that the plastic shields should be removed when doing this and the pack support structure should be looked at and touched up with paint if needed. While you are under the car, check for any oil leaks around the reduction gear (transmission) and if you find any, check the oil level. Check the parking brake for excessive travel which would indicate the need for adjustment or rear brake service. As these cars age, the rear brake drums should be removed, internal parts cleaned and checked for wear. Front disc brake linings should be inspected along with the discs for wear. Check the brake hose condition. Take the rear motor compartment cover off and check that it isn't packed with dirt and check the coolant level in the bottle on the left side. Check all the coolant lines for hose leaks, cracks, etc. Some cars are nearing five years old at which point the coolant needs to be changed to keep the level of corrosion inhibiters up to the proper level of protection. Do this at your own risk, but if there is a lot of dirt and road salt present in the compartment it should be cleaned paying attention not to get water near the vacuum pump air discharge. I've never had a problem but also avoid high pressure spay (like from a quarter car wash nozzle) away from direct contact with the electrical connectors. Lots of soap and a good rinse should do the job. Under the hood, check that the radiator and condenser are clean and the fan turns freely. Check the water level in the 12 volt battery and make sure the terminals are clean and tight. And if the battery looks original, replace it with a new battery that isn't the cheap junk that came with the car. It's amazing how many problems occur with these cars due to a low 12 volt battery. Finally, for your own comfort, don't forget to change the cabin air filter. These cars don't require a lot of maintenance but common sense based on the conditions they operate in dictates some maintenance needs to be done. If you feel comfortable you should do it your self and learn a little more about these great little cars. If not, ask the dealer to do EV specific maintenance for you or for normal "car" maintenance go to any trusted independent mechanic you may choose.

JoeS
Site Moderator
Posts: 3630
Joined: Thu Dec 15, 2011 5:47 am
Location: Los Altos Hills, California

Re: Annual inspection and "required" maintainence?

Fri Aug 12, 2016 10:42 am

siai47, thank you for the excellent and comprehensive summary! I will add that checking tire pressures (especially on an SE with alloy rims) should be done monthly.
EVs: 2 Wht/Blu SE Prem., '13 Tesla MS85, 3 156v CorbinSparrows (2 Li-ion), 24v EcoScoot(LiFePO4)
EV Conv: 156v '86 Ram PU, 144v '65 Saab 96
Hybrids: 48v1kW bike
ICE: '88 Isuzu Trooper. Mothballed: '67 Saab (orig.owner), '76 MBZ L206D RHD RV

pbui19
Posts: 148
Joined: Tue Jan 07, 2014 12:17 pm

Re: Annual inspection and "required" maintainence?

Mon Feb 11, 2019 2:33 pm

hello everyone,

I finally get around to bring my 2014 with 21Kmiles in for the airbag recall. The dealer insisted that I need to do the Maintenance (~$4xx) in order to keep the warranty. I thought that's a bit steep; and the main items listed in the Maintenance schedule are high voltage cabling inspection and gear box oil level check. The 2014 schedule doesn't even list the pack capacity test as a requirement. I am thinking of just clearing out the wrench icon and wait for warmer weather to check the gear box oil level.

I am a bit concerned about the Inverter/Charger/DCDC unit going out, but the dealer said there hasn't been any. In fact, I've been using a lot more QCDC. Really wish there's a way to limit QC rate to 20kw or less.

thoughts ?

Return to “General / Main Owners Forum”